ATCHISON, Kan. (AP) - Crews suspended their search Sunday for three people missing after a thunderous explosion at a Kansas grain elevator killed three workers and hospitalized two others with severe burns.
The blast, which shook the ground so hard that it was felt into neighboring Missouri, is a harrowing reminder of the dangers workers face inside elevators brimming with highly combustible grain dust at the end of the harvest season.
The explosion Saturday night at the elevator in Atchison, about 50 miles northwest of Kansas City, sent an orange fireball into the night sky, shot off a chunk of the grain distribution building directly above the elevator and blew a large hole in the side of the one of its concrete silos.
Officials with Bartlett Grain Co., which owns and operates the elevator, decided to temporarily halt the search for the three missing people - one worker and two grain inspectors - because it was unsafe to be inside the facility, said Atchison City Manager Trey Cocking. Smoke could still be seen billowing from the top, and officials were fearful the building could fall on top of rescue crews.
Heavy equipment, federal safety investigators and engineers were expected to arrive later Sunday to assist the crews.
"It's a fairly dangerous situation. We don't feel comfortable putting fire crews in," Cocking said.
He said crews had not given up hope that they would find the remaining three alive, although the search was now considered a recovery effort. The victims' names had not been released by Bartlett Grain as of Sunday evening.
One of the missing was Travis Keil, a war veteran who had served as a site inspector for 16 years. His parents, Gary and Ramona Keil, drove from Salina to Atchison, to wait with his three children - ages 8, 12 and 15 - as crews searched.
"We have all our prayers working for him," Gary Keil said. "It's a parent's worst nightmare to go through this."
Bartlett Grain President Bill Fellows said in a statement that workers were loading a train with corn when the explosion occurred, but the cause was not immediately known.
Over the past four decades, there have more than 600 explosions at grain elevators, killing more than 250 people and injuring more than 1,000.
When grain is handled at elevators, it creates dust that floats around inside the storage facility. The finer the grain dust particles, the greater its volatility. Typically, something - perhaps sparks from equipment or a cigarette - ignites the dust. That sends a pressure wave that detonates the rest of the floating dust in the facility.
Fireballs are a common feature of grain dust explosions, where intense heat from the blast can reach 1,500 to 2,000 degrees.
Dust from corn is among the most dangerous. Most dust explosions happen in late summer and early fall when old, dried grain is being cleaned out of elevators in preparation for the harvest. Freshly harvested corn is less explosive because its wetter.
The Atchison facility where the blast occurred has not been cited for any violations in the last 10 years, according to OSHA data, though Bartlett Grain Co. was cited after two people died in separate incidents at two of its other facilities. Neither of those fatalities involved explosions at grain elevators.
The two people injured in the explosion were taken to the burn unit at University of Kansas Hospital in Kansas City, Kan., hospital spokesman Dennis McCulloch said. One was listed in critical condition Sunday evening and the other was in serious condition, he said.
Cocking said four other people, including one woman, escaped without injuries. No names were being released pending notification of families.